User manual KOHLER SH265

[. . . ] Courage SH265 HORIZONTAL CRANKSHAFT OWNER'S MANUAL HORIZONTALE KURBELWELLE BETRIEBSANLEITUNG MANUALE DEL PROPRIETARIO ALBERO MOTORE ORIZZONTALE ÁRBOL DE CIGÜEÑAL HORIZONTAL MANUAL DEL OPERADOR VILEBREQUIN HORIZONTAL MANUEL DE L'UTILISATEUR EN DE IT ES FR 1 A B C D K J G I F H E F E 2 A 4 A B A B C 3 5 A A B B 2 6 A 9 A 7 10 A A 8 11 A A 3 12 STOP 15 A B A C D E F G 13 A H 14 A 16 D A C B 4 17 B A 20 A C 18 A 21 B A C B 19 A 22 IMPORTANT ENGINE INFORMATION THIS ENGINE MEETS U. S. EPA PH2, EC STAGE II (SN:3) AND CA 2008 AND LATER TER EXH EMISSION REGS FOR SI SOR SORE B FAMILY TYPE APP DISPL. A BUILD DATE EMISSION COM MISSION COMPLIANCE PERIOD: P PA: EPA: CARB: TIFIED CERTIFIED ON: REFER TO OWNER'S MANUAL FOR HP RATING, SAFETY, MAINTENANCE AND ADJUSTMENTS. KOHLER, WISCONSIN, USA CRAFTED IN CHINA 1-800-544-2444 kohlerengines. com S AM LE P 11236 IMPORTANT ENGINE INFORMATION THIS ENGINE MEET U. S. [. . . ] For an overhauled engine, use Kohler 10W-30 service class SJ or higher oil for the first 5 hours of operation. Refill with service class SJ or higher oil as specified in Oil Type. Change the oil while the engine is still warm. Make sure the engine is level when filling, checking, or changing the oil. To keep dirt, debris, etc. , out of the engine, clean the area around the dipstick/oil fill plug (F) before removing it. Fill the crankcase with new oil of the proper type, up to the point of overflowing the filler neck. Reinstall the dipstick/oil fill plug (A) and gasket (B), and tighten securely. 6. EN 5. 7. NOTE: Over-tightening the dipstick/oil fill plug (A) will distort the gasket (C) and may cause oil weeping. See Figure 4. Service Air Cleaner Element See Figure 15 Yearly or 100 hours (which ever comes first) of operation (more often under extremely dusty or dirty conditions), replace the paper element. Separate the precleaner (D) from the element (F) and service as outlined in Service Precleaner. Oil SentryTM Some engines are equipped with an optional Oil SentryTM switch. This switch is designed to prevent the engine from being started in a low-oil or no-oil condition. The Oil SentryTM may not shut down a running engine before damage occurs. NOTE: Check the oil level BEFORE EACH USE and maintain to the correct level. This includes engines equipped with Oil SentryTM. 2. Service Precleaner and Air Cleaner Element See Figure 15 These engines are equipped with a replaceable, high-density paper air cleaner element (F). Some engines are also equipped with a pre-oiled, foam precleaner (D), which surrounds the paper element. NOTE: Do not wash the paper element (F) or use pressurized air, as this will damage the element. Replace a dirty, bent, or damaged element with a genuine Kohler element. Handle new elements carefully; do not use if the sealing surfaces are bent or damaged. 11 4. Slide the precleaner (D) and paper element (F) onto the air cleaner stud (G). Reinstall the air cleaner cover (B) and secure with wing nut (A). Replace with a Kohler fuel filter yearly or every 50 hours of operation. Removing the air filter cover will allow easy access to the fuel filter for servicing. 5. Fuel Tank Screen See Figure 17 A serviceable fuel tank screen is located under the fuel tank cap, in the filler neck. Ignition This engine is equipped with a dependable maintenance-free ignition system. Other than periodically checking/replacing the spark plug, no adjustments are necessary or possible with this system. In the event starting problems should occur that are not corrected by replacing the spark plug, see your Kohler Engine Service Center. NOTE: Some engines may be equipped with components that comply with RFI regulations. Explosive Fuel can cause fires and severe burns. [. . . ] cannot deny warranty solely for the lack of receipts or for your failure to assure that all scheduled maintenance was performed. may deny warranty coverage if the engine or a part has failed due to abuse, neglect, improper maintenance or unapproved modifications. Call 1-800-544-2444 or access our web site at: www. KohlerEngines. com, for the names of the nearest service centers. The warranty repairs should be completed in a reasonable amount of time, not to exceed 30 days. (b) (c) If you have any questions regarding warranty rights and responsibilities, you should contact Kohler Co. [. . . ]