User manual KOHLER TH575

[. . . ] OWNER'S MANUAL KOHLER TRIAD OHC TH520-TH650 HORIZONTAL CRANKSHAFT 1 Safety Precautions To ensure safe operations please read the following statements and understand their meaning. Also refer to your equipment owner's manual for other important safety information. WARNING Warning is used to indicate the presence of a hazard that can cause severe personal injury, death, or substantial property damage if the warning is ignored. CAUTION Caution is used to indicate the presence of a hazard that will or can cause minor personal injury or property damage if the caution is ignored. [. . . ] Never operate the engine with the oil level below the "L" mark or over the "F" mark on the dipstick. Oil SentryTM Some engines are equipped with an optional Oil SentryTM oil pressure switch. If the oil pressure decreases below an acceptable level, the Oil SentryTM will either shut off the engine or activate a warning signal, depending on the application. 8 8. Fill the crankcase with new oil, of the proper type, to the "F" mark on the dipstick. Stop the engine, allow a minute for the oil to drain down, and recheck the level on the dipstick. Make sure oil level is up to, but not over the ``F'' mark on the dipstick. Oil SentryTM Service Precleaner and Air Cleaner Element This engine is equipped with a replaceable, high density paper air cleaner element. Most engines are also equipped with an oiled, foam precleaner which surrounds the paper element. NOTE: Operating the engine with loose or damaged air cleaner components could allow unfiltered air into the engine causing premature wear and failure. Change Oil Filter Replace the oil filter at least every other oil change (every 200 hours of operation). 12 050 01-S 28 050 01-S 277233-S Replace the oil filter as follows: 1. Before removing the oil filter, clean the area around the oil filter to keep dirt and debris out of the engine. Allow a minute or two for the oil to be absorbed by the filter material. Apply a thin film of clean oil to the rubber gasket on the new filter. Turn the oil filter clockwise until the rubber gasket contacts the filter adapter or oil cooler, then tighten the filter an additional 2/3 to 1 turn. Wing Nuts Rubber Grommet Element Cover Air Cleaner Element Precleaner 7. Standard 28 083 02-S Top Tank 28 083 06-S Service Paper Element Every 100 hours of operation (more often under extremely dusty or dirty conditions) replace the paper element. Clean the area around the element to prevent debris from getting in the engine when element is removed. Remove the element cover wing nuts, element cover, and paper element with precleaner. Do not wash the paper element or use pressurized air, as this will damage the element. Replace a dirty, bent, or damaged element with a genuine Kohler element. Handle new elements carefully; do not use if the sealing surfaces are bent or damaged. If they are worn, damaged, or their condition is questionable in any way, replace them with the new seals packaged with the new element. Reinstall the paper element, precleaner, element cover, element cover nut, and air cleaner cover. [. . . ] recommends that you retain all receipts covering maintenance on the engine, but Kohler Co. cannot deny warranty solely for the lack of receipts or for your failure to assure that all scheduled maintenance was performed. may deny warranty coverage if the engine or a part has failed due to abuse, neglect, improper maintenance or unapproved modifications. Call 1-800-544-2444 or access our web site at: www. kohlerengines. com for the names of the nearest service centers. [. . . ]